literature review on replacement of fine aggregate by quarry dust

Use of Quarry Dust as fine aggregates by Partial ...

LITERATURE REVIEW:- 1. Radhikesh et al (2010) Quarry dust has been used for ... Replacement of fine aggregate by quarry dust at partial replace results the increase in strength of concrete. 2. The concept of replacement of natural fine aggregate (sand) by quarry dust

The Utilization of Quarry Dust as Fine Aggregates in Concrete

2 Literature Review ... study was to experimentally determine the feasibility of use of quarry dust in replacement of sand in conventional concrete. During the tenure of the study, the study material i.e. quarry dust was collected from a ... Utilization of Quarry Dust as Fine Aggregates... V. Agrawal, P. Shah, A. Gupta and R. Shah 174.

Partial Replacement of Fine Aggregates with Quarry Dust ...

Powder (CPR)/Quarry dust (QD) as fine aggregate in cement concrete, replacing natural sand. The study on concrete includes determination of compressive strength and split tensile strength of different grades of concrete. Properties of aggregate affect the durability and performance of concrete, so fine aggregate

(PDF) EXPERIMENTAL STUDY ON REPLACEMENT OF FINE

Jan 01, 2014 · LITERATURE REVIEW. Nagabhushana et al ... tensile strength of concrete made using quarry dust as replacement of fine aggregate at 0, 25, 50, 75, and 100%. ... by replacing 50% of fine aggregate ...

Strength Characteristics of Quarry Dust in Replacement of Sand

The replacement of natural fine aggregate by using quarry dust leads to consumption of generated quarry dust, the requirement of land fill area can be reduced and solves the natural sand scarcity ...

Use of Quarry Dust to Replace Sand in Concrete – An ...

at 50% replacement. Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today. The constituents of concrete are coarse aggregate, fine aggregate, binding material and water. Rapid increase in

EXPERIMENTAL STUDY ON REPLACEMENT OF FINE

Phase 1: Replacement for fine aggregates Phase 2: Replacement of Binders Phase 3: Replacement of Coarse Aggregates Presently the research work is preceding on Phase 1: Replacement of conventional fine aggregate (sand) by Quarry dust. Following are the step has to be carried out in the experimental studies of phase 1. 1. Sieve analysis of QD 2.

A Technical Review on Quarry Dust and Foundry Sand Used As ...

A Technical Review on Quarry Dust and Foundry Sand Used As Fine Aggregates in Mortar Mehulkumar R. Rathod1 Prof. Poonam I. Modi2 1P.G Student 2Assistant Professor 1,2Department of Applied Mechanics 1,2L. D. College of Engineering, Ahmedabad, India – 380015 Abstract— Sustainable construction is the need of our.

Optimum Mix of Quarry Dust as Partial Replacement of Fine ...

1.1 Literature Review . ... material instead of fine aggregate. Also, the use of quarry dust as the fine aggregate decreases the cost of concrete production in terms of the partial replacement for ...

Partial Replacement of Fine Aggregates with Quarry Dust ...

Powder (CPR)/Quarry dust (QD) as fine aggregate in cement concrete, replacing natural sand. The study on concrete includes determination of compressive strength and split tensile strength of different grades of concrete. Properties of aggregate affect the durability and performance of concrete, so fine aggregate

literature review on replacement of fine aggregate by ...

CHAPTER 2 LITERATURE REVIEW 2.1 GENERAL This chapter presents an overview of literature on the various experiments conducted by many authors on the replacement of fine aggregate by quarry dust, manufactured sand and the results thereof highlighting the significance of using the manufactured sand for replacing the natural sand in concrete.

IOP Conference Series: Materials Science and Engineering ...

2. LITERATURE REVIEW The suitability of quarry dust as a sand replacement material shows that the mechanical properties are enhanced and also elastic modulus. The compressive strength analysed optimum by replacing fine with quarry in ratio of 60:40 said by Azar Hamid Mir [1].

(PDF) QUARRY ROCK DUST AS A PARTIAL REPLACEMENT OF FINE ...

Opportunity: Quarry dust can be used as partial replacement of fine aggregate and cement. Past Past studies have shown that QD can be partially replaced up to 25% & up to 10 % as cement and F.

EXPERIMENTAL STUDY ON REPLACEMENT OF FINE

Phase 1: Replacement for fine aggregates Phase 2: Replacement of Binders Phase 3: Replacement of Coarse Aggregates Presently the research work is preceding on Phase 1: Replacement of conventional fine aggregate (sand) by Quarry dust. Following are the step has to be carried out in the experimental studies of phase 1. 1. Sieve analysis of QD 2.

A Technical Review on Quarry Dust and Foundry Sand Used

A Technical Review on Quarry Dust and Foundry Sand Used As Fine Aggregates in Mortar Mehulkumar R. Rathod1 Prof. Poonam I. Modi2 1P.G Student 2Assistant Professor 1,2Department of Applied Mechanics 1,2L. D. College of Engineering, Ahmedabad, India – 380015 Abstract— Sustainable construction is the need of our.

(PDF) Concrete With Ceramic Waste And Quarry Dust Aggregates

ceramic waste coarse aggregate and quarry dust fine aggregates concrete more less cohesive. and workable than con v entional concrete becaus e high water absorption of cera mic waste and. quarry ...

STUDY ON THE REPLACEMENT OF CEMENT AND FINE AGGREGATE

The developing countries are under pressure to replace fine aggregate in concrete by an alternate material without compromising the quality of concrete.Quarry dust has become a good substitute for conventional river sand for its total replacement and thus quarry dust concrete (QDC).Recently, the trend of using the fine fractions of quarry dust ...

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF FINE ...

replacement of fine aggregate with quarry dust and sawdust. Quarry dust and sawdust which are by-products generated from stone crushers and wood processing work abundantly available all over the regions. Generally the availability of sand becomes a difficult task, especially in Kerala. In

previous projects on replacing stone dust as fine aggregate

CHAPTER 2 LITERATURE REVIEW - Shodhganga; concrete with the replacement of fine aggregate by manufactured sand. 2.2. QUARRY FINES FROM ... aggregate fines in concrete. The focus of this project was to examine the methods and test procedures used in the past to .... replacement of natural river sand by crushed stone dust waste can attain the ...

(PDF) Feasability Studies of Partial Replacement of Cement ...

IJIRST –International Journal for Innovative Research in Science & Technology| Volume 4 | Issue 1 | June 2017 ISSN (online): 2349-6010 Feasability Studies of Partial Replacement of Cement by Brick Powder & Sand by Quarry Dust B. Pavan Kumar M. Lakshmi Kumar PG Student Assistant Professor Department of Civil Engineering Department of Civil Engineering DNR College of Engineering &

A Study on Partial Replacement of Cement with Metakaolin ...

cement replacement and Quarry dust as partial fine aggregate replacement. Grade of concrete: M40. The . Percentage of replacements are 0, 2.5,5,7.5,10,12.5 & 15 % . for Metakaolin and 0,10,20,30,&40% for quarry dust. The . maximum compressive as well as split tensile strengths . were obtained at. replacements, 10% of cement wi. th

Replacement Of Coarse Aggregate In Concrete - [Civil Planets]

Quarry dust For Partial Replacement The bricks, tile & other lightweight materials are made from the quarry dust. The chemical composition of quarry dust is mostly the same as granite rock. So the strength and durability of quarry dust are good to use in concrete.

Investigations on Various Concrete Properties by ...

Table 2. Tests for Fine Aggregate, Coarse Aggregates and Water Absorption. S.No. Properties S.No Test Results Retained Standard Value 01 Fine Aggregate Stone Dust (Replaced) Sand (Actual) 02 Specific Gravity of Fine Aggregate 2.47 2.5 03 Specific Gravity of Coarse Aggregate 2.86 2.5-3.0 04 Water Absorption 0.15% Up To 2.0% Table 3. Impact Value.

A LITERATURE REVIEW ON INTERNAL CURING OF CONCRETE

Iftikhar et al. (2015) [12] in this study fine aggregate is replaced by Pre-saturated saw dust at three replacement levels of 5, 10 and 15% by mass respectively. Form the result it is found that the internally curing can be effective achieved when fine aggregate is replaced by 5% of saw dust.

Experimental study on replacement of fine aggregate in ...

Dec 01, 2019 · Aggregates. Fine aggregate used in this research is natural sand, manufactured sand, and quarry dust. The physical property determined under IS 2386-2016 . The angular shape coarse aggregate of size is 20 mm and below. The physical properties of coarse aggregate determined under IS: 2386-1963. 2.1.3. Water

Study on Partial Replacement of Fine Aggregate by Quarry ...

Mar 08, 2017 · The study explains that quarry dust has required properties of fine aggregate and 50% of quarry dust can be replaced in sand to produce optimum strength of concrete. 25% replacement of quarrydust with fine aggregate gives same strength values as control mix Durability studies reveals that Ph value between 12.5 to

Literature Review on Different Waste Plastic Material and ...

Literature Review on Different Waste Plastic Material and Sand in Paver ... Concrete” study the Partial replacement of fine aggregate in different percentage as like 0%, 20%, 40%, 60%, 80% and ... (plastic waste : quarry dust: coarse aggregate : quarry dust ) gives maximum Compression strength- 13.03 N/mm2 And Paver block taken in oven for 2 ...

Experimental Study on Granite Powder as a Replacement of ...

LITERATURE REVIEW 2.1 GENERAL ... support for the use of Quarry Rock Dust as fine aggregate in concrete Manufacturing. Thus, it can be conclude that the replacement of natural sand with Quarry Rock Dust, as full replacement in concrete is possible. The reduction

Experimental Study on Use of Quarry Dust and Fly Ash with ...

aggregates. In this experimental study an attempt will be made to find the effect of partial replacement of Fine aggregate by Quarry Dust and Cement by Fly ash. The innovative use of Quarry Dust in concrete formulations as a fine aggregate replacement in the range of 0%, 15%, 30% & 45% by weight for M-40 grade cement (PPC).

BEHAVIOR OF CONCRETE ON REPLACEMENT OF SAND

Table - 3.1. Physical properties of quarry rock dust and natural sand Fine aggregate (Natural river sand): River sand having of 1813.33 kg/m3 odulus of 2.015 was used. The specific gravity was found to be 2.5. Table - 3.2. Sieve analysis for sand Fine aggregate (Quarry stone dust): Quarry Stone dust used in the laboratory investigations was

INVESTIGATION OF STRENGTH CHARACTERISTICS ON

1. To hold out the literature review for comprehensive study on partial replacement of sand by saw dirt as fine aggregate in concrete mixture. 2. To mix saw dust sample with sand in 10%, 20%, 30% and 40% and record the detail observations to check efficient percentage of the saw-dust that can be replaced by sand in the construction field. 3.

(PDF) Feasability Studies of Partial Replacement of Cement ...

IJIRST –International Journal for Innovative Research in Science & Technology| Volume 4 | Issue 1 | June 2017 ISSN (online): 2349-6010 Feasability Studies of Partial Replacement of Cement by Brick Powder & Sand by Quarry Dust B. Pavan Kumar M. Lakshmi Kumar PG Student Assistant Professor Department of Civil Engineering Department of Civil Engineering DNR College of Engineering &

previous projects on replacing stone dust as fine aggregate

CHAPTER 2 LITERATURE REVIEW - Shodhganga; concrete with the replacement of fine aggregate by manufactured sand. 2.2. QUARRY FINES FROM ... aggregate fines in concrete. The focus of this project was to examine the methods and test procedures used in the past to .... replacement of natural river sand by crushed stone dust waste can attain the ...

Partial Replacement of Sand with Quarry Dust in Concrete ...

-The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust, a by-product from the crushing process during quarrying activities is one of such materials.

Table 2 from Partial Replacement of Sand with Quarry Dust ...

Partial Replacement of Sand with Quarry Dust in Concrete. -The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates

partial replacement of fine aggregate by glass powder in ...

Apr 05, 2015 · The partial replacement of glass powder as fine aggregate Makes the concrete strengthen. Thus our project states that concrete can be strengthen by glass powder replacement , which makes the waste in to useful, so the waste materials made in to use.

XRD Analysis of Natural sand, Quarry dust, waste plastic ...

Jan 01, 2018 · Saifuddin (2001)[8] studied the influence of partial replacement of sand with quarry dust and cement with mineral admixtures on the compressive strength of concrete (Gambhir, 1995), whereas Celik and Marar[10] investigated the effect of partial replacement of fine aggregate with crushed stone dust at different percentages in the properties of ...

Copyright © 2020.Company name All rights reserved.SiteMap